Enhanced treatment of flush-dairy manure in anaerobic sequencing batch reactors using a cationic polymer

Anaerobic sequencing batch reactors (ASBR) are preferred for treating dilute wastewaters but the retention of adequate active biomass, in successive-cycles, is always a challenge. This research investigated the efficacy of using a cationic polyacrylamide (PAM) flocculant for enhanced sludge retention in an ASBR treating flushed dairy manure, operated under psychrophilic conditions. Three PAM doses (10, 25, and 50 mg [PAM] l−1) were tested in duplicate reactors. At 6 d hydraulic retention time (HRT) and dosing of the feed-manure, steady state specific biogas yield for the 50 mg [PAM] l−1 treatment was 491 ± 7 ml g−1 [TCOD] (56% greater than control). At 4 d HRT the 50 mg [PAM] l−1 dose resulted in 465 ± 8 ml g−1 [TCOD] (20% higher than the control) at steady state conditions. The ratio of total volatile fatty acid to alkalinity was 0.29 ± 0.08 during the 6 d HRT and 0.14 ± 0.02 during the 4 d HRT, which were both below the trigger point for digester souring. This study shows that the use of PAM for high sludge retention in ASBR is a viable approach for, not only enhancing biogas yield, but also for improved and high-rate treatment of flushed dairy manure under psychrophilic conditions. •Enhanced retentions of solids and active biomass were investigated in this study.•The polyacrylamide (PAM) was effective in separating the SRT from the HRT.•Approximately 56% more CH4 was realised from the 50 mg [PAM] l−1 dose.•The PAM treatment did not negatively impact the digester health.•Continuous PAM pretreatment may adversely affect AD of the dairy wastewater.