Enhanced coagulation by high-frequency ultrasound in Microcystis aeruginosa-laden water: Strategies and mechanisms

•The frequency affected the removal slightly compared with the acoustic power density and the duration.•The release of protein played a significant role in coagulation.•The instantaneous high pressure of the rupture of cavitation bubbles collapsed the gas vesicles. Ultrasonic treatment has attracted much attention because of its physical and chemical effects that are distinct from those of chemical agents. In particularly, high-frequency ultrasound is known as an effective method because the theoretical resonance frequency of the gas vesicles in Microcystis aeruginosa is in the high frequency range (>100 kHz), which causes gas vesicles collapse and changes the settleability of the algal cells. In this work, the effects of the ultrasonic frequency, acoustic power density and duration on enhancing coagulation to remove turbidity in algae-laden water were studied. In order to explain the mechanism, the morphology of algae cells, the changes in extracellular organic substances, the zeta potential and the formation of hydroxyl radicals were analyzed systematically. Finally, Zeta potentials and flocs morphology after adding PAC were investigated to verify the mechanism. The results showed that the frequency exhibited fewer effects than power and duration on coagulation. SEM images showed that there were more severe cellular damages at 430 and 740 kHz than other frequencies. Sonication could cause the collapse of gas vesicle inside the cell, which was due to the instantaneous high pressure generated by the ultrasonic cavitation instead of the resonance. Furthermore, sonication would result in an increase in proteins in extracellular organic matter (EOM) with continuous ultrasonic irradiation, indicating that a small amount of proteins could promote coagulation and that the accumulation of proteins would inhibit coagulation. Free radical content testing showed that the production of excessive free radicals was often accompanied by a deterioration of the coagulation. The proper mechanical effects were the main mechanism of ultrasonic enhanced coagulation. Thus, it was recommended that the appropriate ultrasonic condition was the one that resulted in a small amount of protein leakage and little generation of free radicals, which occurred at 740 kHz and 0.02 W/mL in approximately 5 min, and would significantly enhance the turbidity removal rate in algae-containing water from approximately 80–90%.